What is a sidewall slug?

The Sidewall Slug is for a Sidewall Tear up to 1.5 inches. This is for emergency use only. Once installed properly you will be able to continue driving your off road vehicle back to your starting point. You will need a 10mm wrench and a set of Pliers.

What is considered a sidewall puncture?

Any puncture less than 1/2 inch from the start of the internal steel belt on the shoulder or sidewall of the tire cannot be repaired (highlighted in red). A tire puncture greater than 1/4 inch (or 6mm) cannot be repaired. A new tire replacement is needed if a puncture exceeds this limit.

Are sidewall punctures repairable?

The puncture is within the tread area* of the tire – sidewall punctures are NOT repairable. The tire puncture is ¼ inch in diameter or less. The angle of the puncture is at least 45 degrees or more. The tire does not have another repaired area overlapping the new area to be repaired.

Can I drive with a sidewall puncture?

Can you drive on a tyre with a damaged sidewall? The short answer is no, you should not drive your vehicle if any of the tyre sidewalls are damaged, unless driving to have the problem fixed.

What does sidewall damage look like?

Sidewall tire damage is what it sounds like; damage to the tire's sidewall, meaning the damage is on the side of the tire and not the tire tread. Sidewall tire damages are, in most cases, not repairable. You can often spot one by seeing a deep scratch or a bubble on the tire's sidewall.

Sidewall Slug Installation

How common is a nail in the sidewall?

Yes—and it's more common than many people think. A nail that punctures clean into a sidewall is unlikely to cause an explosion, but a jagged or rusty nail can create a tear that will widen suddenly under extreme circumstances. This is more common on old, worn-out tires than brand new ones, but it's still possible.

Will tire slime fix a sidewall leak?

This means TireJect will not stick to the tread area like Slime tire sealant. While the tire is rotating the tire sealant flows to and seals any leaks in the tread, sidewall and bead area of the tire - can even fix tire dry rot.

How thick are tires sidewalls?

Tire sidewalls vary in thickness from the shoulder area to the bead area. In the thinnest part, typically in the middle to upper area, most sidewalls are between 6- and 15-mm thick – about 1/4- to 5/8-inch thick.

What part of tire is not repairable?

Puncture repairs are limited to the center of the tread area. If there are punctures or damage in the shoulder or sidewall of the tire, it is not repairable.

Why do new car tires wear out so fast?

New tires or factory tires wear out quickly because car manufacturers use soft rubber for their tires. This soft rubber wears out much faster than aftermarket tires.

How can you tell if someone slashed your tires?

Completely flat tire

A slashed tire will deflate much faster than a blown tire. Depending on the severity of the damage, a slashed tire can go from full to flat in a matter of seconds. If your tire looks less like a donut and more like a pancake, then it was probably slashed.

What does R mean on a tire?

This is indicated in percentage of the tire width. “R” stands for the construction method of the tire indicating the tire is a radial tire. The following two numbers (16) indicate the diameter of the wheel rim in inches. The next two or three numbers (94) indicate the load index of the tire.

What causes sidewall tire damage?

Road hazards include potholes, debris, and curbs, which can leave a cut or a puncture in the tire. The damage may be immediate, making the tire go flat or explode, or it may be long-lasting. The latter will expand and eventually deflate the tire fully, causing a tire sidewall blowout.

What does XL mean on a tire?

XL (or Reinforced) tyres are 'extra load' tyres – they indicate that a tyre is reinforced to be able to withstand a higher load than other tyres of the same size.

Does Slime ruin your tire?

If pre-existing damage is present, we do not recommend using Slime tire sealant. Do not leave Slime inside your tires for more than 2 years. After that time, we cannot guarantee the integrity of your rims.

Why do I always have nails in my tires?

When your tires are under-inflated, more of the tire's tread is in contact with the road, resulting in more friction as you drive. When you have too much pressure on your tires, your tires are more susceptible to damage from potholes and other road debris, which increases their risk of occurring.

Can I just leave a nail in my tire?

If you get a Nail in your tire, you should remove it as soon as possible. You can drive short distances with a nail in your tire but you should not just leave it there and continue to drive for a long period of time. It is very unsafe for not only you but the other drivers you share the road with as well.

Can Runflats be repaired?

Although not all manufacturer Run Flat tyres can be repaired, Goodyear Run On Flat Tyres can be repaired by a qualified tyre professional following a thorough inspection and analysis of the tyre history. In case of any doubt, it is recommended that the tyre should not be fixed.

Do tire warranties cover sidewall damage?

If the tire warranty was purchased for the tire, and it's in the recommended spec, and repairable, it will be repaired. If the tire cannot be repaired due to issues like punctures in the sidewall, the tire will be replaced.

Is sidewall damage an MOT failure?

As well as sidewall damage, if there is significant damage to the tread cap or tyre shoulders that expose the cords or ply, it will lead to failing your vehicle's MOT. As per tyre sidewall damage above, any tyre with exposed cords or ply should be replaced immediately.